The Dakotas have faced fuel restrictions for at least the last two years. They're at the far end of the pipeline network and after complete outages in 2007 everyone orders their diesel well in advance. Vehicle tanks are kept fuller and the on farm tanks are not allowed to run low. Gasoline supply dynamics have changed as well; British Petroleum shuttered three hundred stations in the area, citing the high cost of trucking fuel to the locations from the pipeline terminals.

    This year propane is in short supply. Rural homes in that part of the world are heated with propane and the grain elevator and on farm drying require it to bring corn moisture down for storage. There is no sense that homes will go cold this year, at least not due to supply issues; the grain drying season is a short period of intense usage that will draw to an end within the next week. Pray to whatever higher power you recognize that the unheard of figure of 18% of the crop still in the field is brought in before the snow flies.

    The Dakotas were very wet this year and the corn is coming in at 22% moisture. A more usual number would be 18% and for long term storage it must be dried to 14% to avoid spoilage. That doubling in the moisture reduction needed, an 8% drop instead of 4%, pretty much doubles the amount of propane used. Right now the harvest is at a dead stop. What can be dried has been and what is left can't even be combined without the fuel to make it ready for storage; it would all just spoil in the bin if put up wet.

   I wondered if this was a spot problem in that particular part of South Dakota, but Bryan said it was widespread - he'd talked to farmers as far away as St. Louis and they were reporting similar issues.  I made a few calls to try to figure out how broad the problem was. I ended up talking to Rollin Tiefenthaler at fuel dealer Al's Corner in Carroll, Iowa about the issue.

   The Iowa crop comes matures earlier and is brought in earlier, so that is done, but he confirms that propane is being trucked long distances because local terminals have outages. They did have one farmer's cooperative run out of propane and they scrambled to get them enough, but in general it wasn't a problem. These are plains cooperatives, operations with thirty employees, dozens of vehicles, and tens of millions of dollars in inventory and commodities under management, so one running out of fuel is a problem that would affect a whole county.

 Diesel has been a bigger concern for them - instead of the thirty mile drive to the Magellan pipeline terminal in Milford they're running as far as Des Moines or Omaha, each about two hours away, and the added time and cost for running more trucks is eating them alive.

    The die has already been cast in the Dakotas, they'll either get the crop in or they won't. If they don't and it winters in the field they not only lose 40% of the yield on that ground they lose 20% of next year's yield in soy beans. The corn makes an excellent snow fence, trapping drifts six feet high, and they're slow to clear in the spring. The farmers have to wait until it's dry enough to plant before they can finish bringing in the corn crop, then they plant their soy, and that delay cuts into the growing degree days available for the soy beans and thusly we see the yield drop.

   A few of you might not be from farm state and thusly won't know the normal work flow. The corn crop is still partially in the field, but the soy beans are already done. Soy matures and dries earlier, so it gets tended first. There would never been an instance of soy being left to overwinter just based on crop timing and I don't think the small, thin stocks with relatively fragile pods would prove to be terribly durable under snow banks.

   I wrote earlier about the famine potential we face due to the underfertilization of the wheat crop. Wheat that gets enough ammonia is 14% protein, if it is unfertilized closer to 8%, and that 43% reduction in total plant protein is going to cause unimaginable suffering in places like Egypt, where half of the population gets subsidized bread. Global end of season per capita wheat stocks have been about seventy pounds my entire life, except the last three years where they've dropped to only forty pounds. One mistake in this area and one of the four horsemen gets loose, certainly dragging his brothers along behind. That mistake may already have been made in the lack of wheat fertilization this fall.

    The fall nitrogen fertilizer application has been 10% of the norm. A typical year would see 50% put on in the fall and 50% in the spring. During fertilizer application season the 3,100 mile national ammonia pipeline network runs flat out and the far points on the network experience low flow both fall and spring. If they try to jam 90% of the fertilization into a period of time when the system can only flow a little more than half of the need much of our cropland will go without in the spring of 2009.

    Finances as much as weather are the issue with regards to fertilization this fall. Crop prices have fallen to half of what they were, ammonia prices have dropped but ammonia suppliers here, receiving 75% of their supply from overseas, still have product in their storage tanks purchase at the historical highs last spring and summer.

    When farmers plant they record the acreage and they purchase crop insurance - $20 to $40 an acre depending on the crop. If they have a failure they file a claim, an adjustor contacts them, and they get a check to cover the deficit. Some of this runs through the U.S. Department of Agriculture and some of it is through private insurers.

   My conversations with farmers earlier this week lead me to believe that the largest private insurer, Des Moines Iowa's Rain and Hail Agricultural Insurance may be insolvent. Flooding claims from this spring were filed and payments would have typically been received by the end of June or beginning of July. It's now the end of November and payments are not being dispersed. Individual farmers are told there was something wrong with their paperwork, but this is nonsense - some of these guys have been farming thirty years and they all didn't forget how to fill out a simple form all at the same time. Iowa did have its second five hundred year flood in a decade and a half this spring which certainly has something to do with the situation, but I suspect Wall Street's sticky fingers got hold of Rain & Hail's assets, just as they've done to every pension fund and state run municipal investment pool.

  So, we're already facing what Bryan Lutter calls "the mother of all fertilizer shortages" next spring and on top of that local banks won't lend to farmers.

   The local bank was quite willing to lend to a farmer on a crop despite the weather related risks just like they'd lend on a car despite the driving risks. So long as the asset was insured the risk was deemed manageable. There were sure to be losses here and there, but they'd be administrative hassles associated with well known risks. If the auto insurance companies were viewed as untrustworthy no one would be getting a car without 100% down at the dealership and the same rule is now in effect for farmers.

   Farmers without financing can't afford nitrogen fertilizer at $1,000 a ton, which translates to $100 an acre at current application rates. They won't be paying $300 for a bag of 80,000 hybrid corn kernels, again a $100 per acre expense. The average farm size in Iowa is four hundred acres and planting to harvesting would run about $120,000.

   This looks incredibly bad. Bryan and I are both puzzled as to why the mainstream media isn't covering this. Perhaps the need to sell Christmas season advertising trumps the need for the public to know about the troubles that are brewing.

    This is already 1,600 words and I haven't even touched Verasun. Executive summary? The nation's second largest ethanol maker took corn from farmers, went bankrupt without paying many of them, and a whole lot of family farms are going to be foreclosed upon in short order if something isn't done.

Take Action

     The instant the Obama administration and the 111th Congress take their seats, before anything is done about Detroit, before anything is done about pension funds caught up in Wall Street's massive fraud, yes, even before they touch universal health care SOMETHING has to be done to protect our agriculture system from the volatility flowing from Wall Street's death contortions. This won't be a giveaway - it'll be a genuine investment with known risks and known returns for products that will experience ongoing demand. We, as a nation must provide our farmers with a fair, stable financing and insurance system or we're all going to pay a terrible price.

    If you're not in an agricultural state and you see something come up about a plan to address these issues please take the time to call or write your delegation members and let them know that you realize how important this is, even though it doesn't directly affect your state.

My Personal Action

    Perhaps this is the first time you've ever noticed my work. I'm the executive director for the Stranded Wind Initiative, an organization founded to develop local uses for renewable energy in places that don't have transmission lines available. A few months back a small group of the volunteers from SWI formed Third Mode Energy, a commercial venture aimed at building renewable ammonia fertilizer plants. We're working on projects in New York, Iowa, South Dakota, Indiana, and I think one is going to start in Ohio. We're looking for about fifteen more sites nationally and we need local leaders to take these projects in hand. We're going to be producing a package of information on this for legislators and media figures active in environmental and economic issues which will be ready in the first few days of January, with the intent of getting some of that stimulus money directed at local, renewable ammonia production.

   If your town is down and hurting we might just have a partial solution to the need for jobs and energy. We've got a group for more detailed discussion on Kossacks Networking.

   If you look here you will see an article from last spring - our first attempt at plant development for renewable ammonia. That one didn't go but we learned a lot and the story should give you a sense of the renewable fertilizer, greenhouse produce, and other good things that come from such development.

  If you look here you will see an article I did on wheat fertilization on The Cutting Edge News.

(UPDATE:

    This diary spent some time on the rec list at DailyKos - I've kept a few of the updates I posted there as they seem relevant.

    I've received the usual suggestions about how our large scale grain production should be done organically. I have no ideological opposition to this and in fact I'm generally vegetarian and eat organic as much as I can lay my hands on it. The problem is that none of the proponents can describe to me what it would look like to cultivate an entire square mile in that fashion, let alone defining a plan that would allow a neat conversion of all of the forty to fifty thousand square miles of the state of Iowa to such methods. It's an admirable concept, but it doesn't seem executable. I do not at all accept that it's "big agriculture" keeping the farmers down. If there was a way to get similar yields without paying $100/acre for fertilizer and another $100/acre for seed the typical Iowa farmer with his 400 acres would be busy stuff an extra $80,000 a year into the bank. This is not the case today.

   Kossack cordgrass is going to be disappeared to Guantanamo or worse for speaking the truth. Let's wish he or she a fond farewell:

Real news, useful news that could predict the future is no longer in the MSM, precisely because hedge fund managers and people like that make money on the future.  Knowing what is going to happen in the future is money in the bank.  The more people who know the future, the less money the investor will make.

  Here is an article from The Grand Forks Herald about the propane shortage.

  And here is a direct quote regarding the wheat fertilization. The set of numbers indicate a fertilizer with 18% nitrogen, 46% phosphorus, and in this case no potassium. The source was Bryan Lutter, my agronomist friend in South Dakota. I redacted the farmer's name because I don't have permission to publish it.

Neal,

It's very frustrating there is not enough news on the lack of news
surrounding the under-fertilization of USA wheat. Example, [NAME REDACTED] is a large farmer in New Underwood, SD. He normally uses 5 semi loads of MAP (18-46-0) in the fall for his wheat. He used just 1 this year. The wheat is in the ground, and the die cast.

He explained his reasoning for reduced use very well. The extra yield boost costs too much. It's actually cheaper to simply buy the extra bushels which the fertilizer would provide.

Bryan